Owens Corning Underlayment & Deck Repair Nationwide

Owens Corning Underlayment & Deck Repair: The Orlando Owner’s Guide

If your Owens Corning roofing system has a failing underlayment or a soft deck, we stock and install Owens Corning Deck Defense, ProArmor, and RhinoRoof underlayment here in Orlando, with most underlayment and deck repairs on this product line running $1,850 to $6,800 installed depending on how many squares of decking are involved. Most homeowners discover the problem one of two ways: a water stain on the ceiling after an Orlando afternoon storm, or a roofer (often us) finding rotted plywood or a torn synthetic underlayment during a routine leak investigation or a full re-cover. We’re an independent Orlando roofing contractor, not a division of Owens Corning, so our job is to give you honest pricing on the right material and a deck repair that actually holds, not to push their catalog at you.

Call (448) 218-0800

Dylan Pace, the owner of Crestview Roofing Co Orlando, has pulled enough Owens Corning underlayment off Central Florida roofs to know exactly where it fails after years of heat cycling and wind-driven rain. “If it’s not in writing, it’s not a promise, it’s just weather talk” is the rule on every Owens Corning deck and underlayment job we quote.

Which Owens Corning Models This Applies To

Owens Corning makes several synthetic underlayment products, and they are not interchangeable. The two we install most in Orlando are Deck Defense, a reinforced synthetic underlayment with a slip-resistant coating, and RhinoRoof, a heavier, high-traction product built for steeper pitches. We also match repairs to older or current systems that call for ProArmor, which has a skid-resistant surface and is common on recent Owens Corning Total Protection Roofing System installs.

Here’s the compatibility gotcha most homeowners won’t know: Owens Corning’s Total Protection System warranties technically require their underlayment to be installed with their shingles to keep the full manufacturer warranty intact. If you’re doing a partial deck repair on an existing Owens Corning roof, you do not need to pull permits or replace the entire underlayment field, but you do need to match the seam tape and fastener pattern to the original material. We check the weave pattern and any printing on the underlayment edge to identify exactly what you have before we quote. For decking, we generally replace rotted sections with APA-rated CDX plywood at the same thickness as the original deck, usually 7/16 inch or 1/2 inch based on your rafter spacing.

Signs Your Owens Corning Underlayment & Deck Repair Is Failing

• Water stains on ceilings or walls after storms. Orlando gets roughly 51 inches of rain a year, and a compromised underlayment lets wind-driven water through long before the shingles look bad. The water travels along the decking and shows up somewhere you’d never expect.
• Spongy or soft decking when walked on. If the plywood deck under the shingles flexes or feels soft, it’s lost structural integrity. That’s rot, not a cosmetic issue, and it only gets worse in Florida’s humidity.
• Visible underlayment through missing or loose shingles. Owens Corning shingles can break or lift in a serious wind event, especially older 3-tab models. If you can see the underlayment flapping or torn beneath, water has a direct path to the deck.
• Interior drywall tape pulling or paint bubbling on ceilings. That’s a slow leak that’s been feeding moisture into the plywood for months. By the time paint bubbles, the deck almost always needs a section cut out and replaced.
• Curled or shrunken underlayment at eaves and rakes. Older felt or entry-level synthetic underlayment bakes in the Florida sun where exposed and starts peeling back. Once the edge goes, capillary action pulls water under the rest of the system.

Replacement Cost & What’s Included

In Orlando, most partial underlayment repairs run $850 to $2,950, while full roof deck replacement along with Owens Corning underlayment on a standard one-story home lands between $3,900 and $9,700. The spread comes down to how many sheets of plywood have to go back in, roof pitch, and whether the existing underlayment can be patched or has to be torn off and relaid.

Here’s a realistic line-item breakdown for the Orlando market:

Every line item on the quote is separated so you can see the material cost, the labor, the decking, and any disposal. Our written price is final before we touch the roof. And every Owens Corning underlayment or deck repair we do carries the 365-Day Done Right Promise: if the repair fails within a year, we return and correct it at no charge, with no negotiation.

DIY or Call Us?

There are safe things you can check from the ground: missing shingles, visible underlayment flapping, soft spots when you walk a low, accessible area of the roof. But underlayment replacement is not a weekend project. You’re peeling back the entire top layer of the waterproofing system, replacing plywood while the roof is open, and retying it into the drip edge, pipe boots, and wall flashing. Get the seam overlap wrong on Deck Defense and you’ve created a leak channel. Cut a deck panel short of a truss and you’ve created a code violation and a structural weak point. This is not the job to learn on. Call us at (448) 218-0800, tell us what you’re seeing, and we’ll come out, write a real quote, and if we replace the underlayment we’ll photograph the deck before and after so you see the work without having to get on a ladder.

FAQs